Crack Filling for homes and businesses

Asphalt Crack Filling in Springfield, OH

Dan's Asphalt Maintenance does asphalt crack filling in Springfield, OH for driveways, parking lots, and private roads. We clean out cracks and fill them with sealant made for pavement, so water cannot get under the surface. It is a fast, low-cost repair that saves you from much bigger ones.

Call (937) 207-3598 Get a Free Estimate

Drawing of a crack in asphalt being filled with sealant

Every pothole starts as a crack. Water runs in, freezes, expands, and breaks the asphalt apart from underneath. Filling cracks early stops that cycle before it starts.

Free estimates
Commercial and residential
Local 937 number

What Our Crack Filling Includes

Cleaning cracks of dirt, weeds, and loose material
Filling cracks with flexible pavement sealant
Long cracks along driveway edges and seams
Spider-web and block cracking in parking lots
Honest advice when an area needs patching, not filling
Prep for sealcoating the same season

How Crack Filling Works

1
Walk the surface
We look at every crack, how wide it is, and whether the asphalt around it is still solid.
2
Clean out the cracks
Cracks are cleared of dirt, weeds, and loose bits. Sealant only holds if it sticks to clean, dry asphalt.
3
Fill and seal
Sealant is worked into each crack and leveled off so water runs over it instead of into it.
4
Next steps
We point out any spots that are breaking up and need patching, and whether a sealcoat makes sense now.

Why Crack Filling With Dan's Makes Sense

Crack filling is one of the six services on our card because it is the best value in asphalt care. A few hours of work now can push back a full repave by years.

We do the whole range, from crack filling to sealcoating to new paving, so we have no reason to upsell you. If filling is all you need, that is what we will tell you.

What Affects Crack Filling Cost

Crack filling is usually priced by the job or by the amount of cracking. After a free look, it comes down to:

Total length of cracks: More feet of cracks means more sealant and more time.
Crack width: Wide cracks take more material and may need backer or patching.
Cleaning needed: Cracks full of weeds and packed dirt take longer to prep.
Condition around the crack: Crumbling edges or alligator cracking may call for patching instead.
Combined work: Filling and sealcoating in one visit usually costs less than two separate trips.

Why Cracks Matter More Around Springfield

Southwest Ohio goes through many freeze and thaw cycles every winter. Temperatures bounce above and below freezing for weeks at a time. Each time water in a crack freezes, it expands and pushes the crack wider. By spring, a hairline crack from last fall can be a pothole.

Clay-heavy soils in this part of Ohio make it worse. Clay holds water, so once water gets under the asphalt through a crack, it stays there and softens the base. That is how you get sunken spots and edges that break off.

Fall is the best time to fill cracks in Springfield, before the first hard freeze. Spring is the second best, to fix what winter opened up. Crack sealant can go down in cooler weather than sealcoat, so crack filling has a longer season.

Crack Filling Questions

When is the best time to fill asphalt cracks?

Fall, before the first hard freeze, so water cannot get in over the winter. Spring is also good for fixing what winter opened up.

What size cracks can be filled?

Most cracks from about a quarter inch up to around an inch wide are good candidates. Very wide cracks, or areas with lots of connected cracks, may need a patch instead.

Is crack filling worth it on an old driveway?

If the base is still solid, yes. It keeps water out and buys you years before you need to repave. If the drive is breaking up everywhere, we will tell you straight that it is time for more.